Opel Frontera

Since 1992 of release

Repair and car operation

Opel of Frontera
+ Cars of mark Opel Frontera
+ Current leaving and service
+ The engine
+ Cooling and heating systems
+ The power supply system and release
+ Engine electric equipment
+ Coupling
+ Manual box of a gear change
+ Kardannye shaft, the main transfer
+ Brake system
+ Suspension bracket and steering
+ Body
- Onboard electric equipment
   Diagnostics of malfunctions of an onboard electric equipment
   Safety locks
   Fusible inserts (thermal relays)
   Chain breakers (thermal relays)
   The relay
   Lighting devices
   Removal and installation of a sound signal
   Servomotor of adjustment of range of light
   Screen wiper
   Cleaner of back glass
   Electric schemes
+ Controls and operation
+ Electric equipment schemes

Safety locks

THE GENERAL DATA

Protection of electric contours of the car is provided with application of a combination of safety locks, breakers of a chain and fusible inserts. The burnt down safety lock is easy for distinguishing from serviceable by survey of its transparent plastic case. Attentively examine a safety lock about its revealing перегорания. If the safety lock outwardly looks normally, but suspicions on its malfunction have remained, make conductivity check between ножевыми the plugs acting from its case.

At replacement of safety locks watch conformity replaceable old on type. The safety locks calculated on a various current strength can outwardly look identical, therefore it is necessary to give special attention to marks. Replacement of the burnt down safety lock on calculated on smaller - and especially big - a current strength is undesirable. Each electric contour requires different degree of protection. Watch that marks on the safety lock case corresponded to a current strength on which the corresponding contour is calculated.

If the replaced safety lock immediately fuses, it is not reasonable to continue its replacement. Before it is necessary to reveal and eliminate its reason выбивания. In most cases that appears short circuit of electroconducting of the contour, caused by breakage or damage of isolation of a wire.
The safety lock breaks off an electric chain at achievement by a current of the established value. Thus protection of the consumer of a current and its chain against damages is carried out. At short circuit, for example, a safety lock расплавляется, protecting a chain.

Relay arrangement
Equally for all executions irrespective of a year of release. A functional purpose of safety locks a miscellaneous.

The main safety locks and the relay are in the block, like shown on an illustration. Here too it is necessary to distinguish blocks depending on models of engines and years of release.

Arrangement of safety locks in the block
Equally for all executions irrespective of a year of release. A functional purpose of safety locks a miscellaneous.

On an illustration safety locks of the car till the end of 1995 of release are shown. Force of rated current of safety locks is resulted. Safety locks protect following chains:
1 - F10E, rated current 10 And, the left headlight, adjustment of range of light, a control lamp of a headlight
2 - F9E, rated current 15 And, the right headlight, a passing light
3 - F8E, rated current 15 And, antifog light
4 - F7E, rated current 20 And, the fan
5 - F6E, rated current 15 And, the fuel pump (the engine of 2.0 l to the middle of 1995 of release and the engine 2.4 )
6 - F5E, rated current 10 And, фароомыватель
7 - F4E, rated current 10 And, a sound signal
8 - F3E, rated current 10 And, the alarm system
9 - F2E, rated current 10 And, parking light and a back lantern left, illumination of the panel of devices, the switch and прикуриватель
10 - F1E, rated current 10 And, parking light and a back lantern right

Separately located safety locks are on positions (11) and (12). The safety lock (11) has rated current 60 And and is designated F11E. It is the main safety lock. The safety lock (12) has rated current 30 And and protects a headlight, signals of turn and the alarm system and diagnostic колодку.

The block of the relay / of safety locks of models between the middle 1995 and the end 1997 of release corresponds the Arrangement of safety locks in the block. Some safety locks carry out other functions:
1 - F10E, rated current 10 And, the left headlight, adjustment of range of light, a control lamp of a headlight
2 - F9E, rated current 15 And, the right headlight, a passing light
3 - F8E, rated current 10А, antifog light
4 - F7E, rated current 25 And, the fan, муфта the conditioner compressor
5 - F6E, rated current 25 And, the fuel pump (the engine of 2.0 l and 2.2 l from the middle of 1995 of release)
6 - F5E, rated current 25 And, cars of early release, 30 And cars of late release, фароомыватель, a sound signal, engine diagnostics
7 - F4E, rated current 30 And, the conditioner fan, right
8 - F3E, only for the diesel engine
9 - F2E, rated current 10 And, parking light and a back lantern left, illumination of the panel of devices, the switch and прикуриватель
10 - F1E, rated current 10 And, parking light and a back lantern right
11 - FL3, rated current 30 And, parking light and back lanterns
      FL4, rated current 30 And, the radiator fan
12 - FL1, rated current 60 And, the main safety lock
      FL2, rated current 60 And, headlights, system of giving of secondary air of the engine of 2.2 l (from the middle of 1995 of release).

On cars since 1997 of release following safety locks are established:
1 - F10E, rated current 15 And, a headlight right, a headlight radiator right, a control lamp of a headlight
2 - F9E, rated current 15 And, a headlight left, a projector left
3 - F8E, rated current 25 And (only for the diesel engine)
4 - F7E, rated current 30 And, the fan, the conditioner fan
5 - F6E, rated current 25 And, the fuel pump (the engine of 2.0 l c the middle of 1995 of release and the engine 2.2 )
6 - F5E, rated current 25 And, the fan, the conditioner condenser
7 - F4E, rated current 10 And, a passing light right
8 - F3E, rated current 10 And, a passing light left
9 - F2E, rated current 10 And, a parking light and a back lantern left, illumination of the panel of devices, the switch also light ватель, the buzzer "Light is included"
10 - F1E, rated current 10 And, a parking light and a back lantern right

These engines have safety locks (11) and (12), protecting following chains:
11 FL3, rated current 30 And, lay and a tail light, antifog light
     FL4, rated current 30 And, the radiator fan
12 - FL1, rated current 60 And, the main safety lock, the heater relay, the conditioner
      FL2, rated current 60 And, headlights

The second block of safety locks takes places under the panel of devices (an illustration the Block of safety locks). Here there are other safety locks. Appointment of safety locks depending on a year of release the following:

Till the end of 1995 of release:
1 - rated current 10 And, the central lock
2 - rated current 10 And, a braking signal
3 - rated current 10 And, internal illumination, radio, hours
4 - rated current 15 And, warmed back glass (release of 1992 ), 20 And since 1993 of release
5 - antifog light
6 - a screen wiper, rated current 15 And till 1992 of release, 10 And since 1993 of release
7 - rated current 15 And, signalling devices of the panel of devices, the turn signals, warmed mirrors of the exterior, warmed nozzles forward стеклоомывателя, a buzzer "Light is included"
8 - a warmed forward seat, rated current 10 And till 1992 of release, 15 And since 1993 of release
9 - ignition system
10 - rated current 10 And, a cleaner and a washer of back glass
11 - rated current 30 And, electric стеклоподъемник, left
12 - rated current 30 And, electric стеклоподъемник, right
13 - rated current 30 And, the switch electric стеклоподъемника, прикуриватель
14 - rated current 10 And, control lamp ABS
15 - a spare safety lock
16 - a spare safety lock
17 - a spare safety lock
18 - it is not occupied
Between the middle of 1995 and the end of 1997 of release
1 - rated current 10 And, the central lock
2 - rated current 15 And, a braking signal, the alarm system gauge
3 - rated current 10 And, internal illumination, radio
4 - rated current 20 And, warmed back glass
5 - rated current 10 And, the antifog light, warmed nozzles forward стеклоомывателя (late release)
6 - rated current 15 And, a screen wiper and стеклоомыватель forward
7 - rated current 10 And, signalling devices of the panel of devices, the turn signals, warmed mirrors of an exterior, a buzzer "Light is included"
8 - a warmed forward seat, rated current 15 And, сдвижной the roof hatch
9 - rated current 15 And, ignition system, the radiator fan, engines H 20 SE and Х 22 ХЕ

At cars of early release: the sound signal, heated nozzles forward стеклоомывателя
10 - rated current 10 And, a cleaner and a washer of back glass
11 - rated current 30 And, electric стеклоподъемник, left
12 - rated current 30 And, electric стеклоподъемник, right
13 - rated current 15 And, the switch electric стеклоподъемника, прикуриватель
14 - rated current 10 And, control lamp ABS
15 - 17 - a spare safety lock
18 - it is not occupied

With the release beginning in 1997 of new model of the car the panel of devices is equipped with the new block of safety locks which takes places behind a cover of the panel of devices on the party of the driver. The block of safety locks contains 24 safety locks and the breaker.
The arrangement of separate safety locks is shown on иллюстр. 3.0c.

The block of safety locks of the car c1997 release

1 - rated current 10 And, the starter relay
2 - rated current 15 And, the fuel pump
3 - rated current 15 And, blocking from stealing, the block of management of injection Motronic
4 - rated current 15 And, ignition system
5 - rated current 10 And, a warmed mirror with the electric drive, warmed nozzles of a washer of a windscreen
6 - rated current 10 And, antifog headlights
7 - rated current 10 And, the panel of devices, ignition
8 - rated current 20 And, the conditioner
9 - rated current 20 And, it is not occupied
10 - rated current 10 And, diagnostics system, protection against stealing
11 - rated current 20 And, a cleaner and a windshield washer
12 - rated current 20 And, a warmed forward seat
13 - rated current 15 And, a stoplight, internal illumination, radio, hours
14 - rated current 10 And, the central lock, protection against breaking
15 - rated current 20 And, signals of turn and the alarm system, back lanterns, a sound signal, illumination of the switch of illumination
16 - rated current 10 And, a cleaner and a washer of back glass
17 - rated current 15 And, warmed back glass, a sound signal, protection against breaking
18 - rated current 15 And, warmed back glass, a sound signal, protection against breaking
19 - rated current 10 And, the fuel pump and atomizers
20 - rated current 15 And, radio, protection against breaking, electric стеклоподъемник, card illumination
21 - rated current 10 And, a control lamp of a pillow of safety
22 - rated current 10 And, system of a pillow of safety
23 - rated current 10 And, ABS
24 - rated current 20 And, the electric drive сдвижного the roof hatch

Safety locks can be replaced. Thus it is necessary to establish a new safety lock of the same rated current. It is important to establish also the reason перегорания a safety lock. Safety locks have colour marks.