Subaru Legacy/Outback

1999-2003 of release

Repair and car operation

The schedule of routine maintenance of cars Subaru Legacy and Outback

The intervals of routine maintenance of the car stipulated in the present Section are calculated on independent performance by the owner of a vehicle of all necessary procedures. Duration of intervals was defined proceeding from the assumption that the car is maintained in a daily mode. Constantly to support a vehicle in peak the forms some of procedures at will of the owner can be carried out slightly more often. Composers of the present Management are assured that receptions of the maximum return from the power unit of the car and its other knots and systems can achieve only under condition of a conscientious attitude of the owner to care of the vehicle. It is not necessary to forget as well about necessity of maintenance of a trade dress of the car on a case of its resale.

At operation of the car in the conditions of strongly dusty district, an intense city cycle (frequent short trips), and also at frequent towage of the trailer, intervals of performance of procedures of routine maintenance should be, whenever possible, are reduced to a minimum.

Servicing of a new vehicle, in order to avoid infringement of factory guarantee certificates, should be made on a firm car repair shop of the company-manufacturer of the car.

Through the first 1600 km (1000 miles) run

· Check up installation of quality of a mix of idling (for models without каталитического the converter) (the Section Check and adjustment of structure of a mix of idling see, - to a forage of the models equipped catalytic with the converter).
· Check up serviceability of functioning противооткатного devices (the Section Check and adjustment противооткатного devices see).

Through the first 5000 km (3000 miles) run

· Make replacement of impellent oil and the oil filter (only for models 3.0 of l with chain drive ГРМ) (the Section Replacement of impellent oil and the oil filter see).

Through each 12 500 km (7500 miles) run or times in 12 months (that will come earlier)

· Make replacement of impellent oil and the oil filter (for all models) (the Section Replacement of impellent oil and the oil filter see).
· Check a condition of the hoses laid in an impellent compartment (the Section Check of a condition and replacement of the hoses located in an impellent compartment see) *.
· Make rotation of wheels (the Section Rotation of wheels see) *.
· Grease chassis components (see Has undressed Greasing of components of the chassis) *.
· Check a condition of components of system of release of the fulfilled gases (the Section Check of a condition of components of system of release of the fulfilled gases see) *.
· Check a condition of seat belts (the Section Check of a condition of seat belts see) *.

Through each 25 000 km (15 000 miles) run or times in 12 months (that will come earlier)

· Check a condition of elements of a suspension bracket (the Section Check of a condition of components of a suspension bracket see).
· Check a condition of components of a steering (the Section Check of a condition of components of a steering drive see).
· Check installation of turns and quality of a mix of idling (for models without каталитического the converter) (the Section Check and adjustment of structure of a mix of idling see, - to a forage of the models equipped catalytic with the converter).
· Check a condition of protective covers and hinges of power shafts (the Section Check of a condition of protective covers of hinges of power shafts see).
· Check a condition of a belt (it) of a drive of auxiliary units (the Section condition Check, adjustment of effort of a tension of belts of a drive of auxiliary units see).
· Check serviceability of functioning противооткатного devices (the Section Check and adjustment противооткатного devices see).
· Check a condition of components of coupling (the Section Check of serviceability of functioning and adjustment of components of coupling see).
· Check a condition of brake disks and brake колодок, in case of need make replacement (the Section of Check and adjustment of brake system see).
· Check serviceability of functioning of a lay brake (the Section of Check and adjustment of brake system see).
· Check a condition of a filtering element of an air cleaner (the Section Replacement of a filtering element of an air cleaner see).

Through each 50 000 km (30 000 miles) run or times in 24 months (that will come earlier)

In addition to the checks listed in the previous subsection:

· Check a condition of brake boots and drums (for models till 2001 of release), in case of need make replacement (the Section of Check and adjustment of brake system see).
· Make check and service of system of cooling (опорожнение, washing and refuelling by a fresh cooling liquid) (Sections Check of a condition of components of system of cooling and Check of a condition and replacement of a cooling liquid of the engine see ).
· Make replacement of a filtering element of an air cleaner (the Section Replacement of a filtering element of an air cleaner see).
· Check a power supply system condition (the Section Check of a condition of components of the power supply system see).
· Check a condition of brake lines and make replacement of a brake liquid (Sections of Check and adjustment of brake system and Replacement of a brake liquid/prorolling of a hydraulic path see ).
· Make replacement ATF (the Section Replacement ATF of automatic transmission see).
· Make replacement трансмиссионного oils Manual transmission (the Section Replacement трансмиссионного oils Manual transmission see).
· Make replacement of greasing of forward and back differentials (the Section Replacement of greasings of back and forward differential see).
· Make replacement of spark plugs (for models 2.0 and 2.5) (the Section Check of a condition and replacement of spark plugs and ВВ electroconductings see).

Through each 100 000 km (60 000 miles) run or times in 48 months (that will come earlier)

In addition to the checks listed in the previous subsection:

· Make replacement газораспределительного a belt (for models 2.0 and 2.5) (the Section Check of a condition and replacement газораспределительного a belt - models 2.0 and 2.5 see).
· Check a condition of the power supply system and make replacement of the fuel filter (Sections Check and replacement of the fuel filter see).
· Make replacement of spark plugs (for models 3.0) (the Section Check of a condition and replacement of spark plugs and ВВ electroconductings see).
· Check a condition of wheel bearings, in case of need make stuffing by their fresh greasing (it is recommended for safe operation of the car) (see the Section Check of wheel bearings).
· Check клапанные backlashes (for the European models) (the Section Check клапанных backlashes see).

Through each 160 000 km (100 000 miles) run

· Check клапанные backlashes (for not the European models) (the Section Check клапанных backlashes see).
· Make replacement of a belt (it) of a drive of auxiliary units (the Section Replacement of belts of a drive of auxiliary units and replacement see).
* The checks marked with an asterisk are included in the Schedule THAT at the initiative of composers of the present Management.

Regular check and replacement газораспределительных chains on l models 3.0 is not required.

At car operation in strongly dusty district make replacement of the air filter more often, than it is stipulated in the Schedule.
Filter ATF is not served part and requires replacement only in case of its mechanical damage or leak ATF.

Operation of cars Subaru Legacy and Outback in intense conditions

At car operation in intense conditions follow the parts listed more low to additional service stations and systems of cars Subaru Legacy and Outback:

In addition to the checks listed in the previous subsections:

· Make replacement of impellent oil and the oil filter (the Section Replacement of impellent oil and the oil filter) see more often, than it is stipulated in the Schedule in following situations:
- At frequent short trips;
- At operation of the car in the conditions of a frosty climate;
- At frequent towage of the trailer.
· Check a power supply system condition each 12 500 km (7500 miles) run, or times in 6 months (that will come earlier) at car operation in areas with the raised maintenance in soil and atmosphere of salt or other substances causing corrosion (in particular, in coastal zones).
· make replacement трансмиссионного oils Manual transmission/ATF and greasings of forward and back differentials at frequent towage of the trailer (Sections Replacement ATF of automatic transmission, Replacement трансмиссионного oils Manual transmission and Replacement of greasings of back and forward differential see ) Is more often .
· Check a condition of brake system, including brake Pads, overlays, disks and drums, and also a lay brake (the Section of Check and adjustment of brake system) each 12 500 km (7500 miles) run, or times in 6 months see (that will come earlier) in following situations:

- At frequent short trips;
- At frequent trips on the bumpy and strongly polluted roads.
- At car operation in areas with the raised maintenance in soil and atmosphere of salt or other substances causing corrosion (in particular, in coastal zones);
- At frequent towage of the trailer.
· Make replacement of a brake liquid (the Section Replacement of a brake liquid/prorolling of a hydraulic path) each 25 000 km (15 000 miles) run, or times in 12 months see (that will come earlier) at operation of the car in the conditions of hilly or mountain district.
· check a condition of elements of a suspension bracket (the Section Check of a condition of components of a suspension bracket see) in following situations Is more often:
- At frequent trips on the bumpy and strongly polluted roads.
- At operation of the car in the conditions of a frosty climate;
- At car operation in areas with the raised maintenance in soil and atmosphere of salt or other substances causing corrosion (in particular, in coastal zones);
- At frequent towage of the trailer.
· Check a condition of protective covers and hinges of power shafts (the Section Check of a condition of protective covers of hinges of power shafts see), and also components of a steering drive (the Section Check of a condition of components of a steering drive) each 12 500 km (7500 miles) run, or times in 6 months see (that will come earlier) in following situations:
- At frequent short trips;
- At frequent trips on the bumpy and strongly polluted roads;
- At operation of the car in the conditions of a frosty climate;
- At car operation in areas with the raised maintenance in soil and atmosphere of salt or other substances causing corrosion (in particular, in coastal zones);
- At frequent towage of the trailer.